Product ID:ENAMEL TYPE OMNI FILL, ENAMEL
MSDS Date:06/02/1987
FSC:8010
NIIN:00N063080
MSDS Number: BYWLB

SPRAYON PRODUCTS

3818 E CORONADO ST
ANAHEIM, CA 92807
US

Emergency Phone: 714-630-1400

Info Phone: 714-630-1400

Cage: 09800

SHERWIN-WILLIAMS DIVERSIFIED BRANDS, INC.

BEDFORD HEIGHTS, OH 44146 US

Telephone: 216-292-7400 OR 216-595-8634

Cage: 09800

BUTYL ALCOHOL; (BUTYL ALCOHOL NORMAL) (SARA 313) (CERCLA)

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: <5%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM, S, C

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHANE, DICHLORO-; (METHYLENE CHLORIDE) (SARA 313)

CAS: 75-09-2

RTECS: PA8050000

Fraction By Weight: 25%

OSHA PEL 500 PPM

ACGIH TLV: 50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

PETROLEUM GAS (LIQUEFIED); (ISOBUTANE/PROPANE HYDROCARBON)

CAS: 68476-85-7

RTECS: SE7545000

Fraction By Weight: 40%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CHLOROCARBON MATLS HAVE PRODUCED
SENSIT OF THE MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE
A SIMILAR EFT IN HUMANS. ADRENOMIMETICS (EG, EPINEPHRINE) MAY BE
CONTRA-INDICATED EXCEPT FOR LIFE-S USTAINING USES IN HUMANS
ACUTELY/CHRONICALLY EXPOSED TO CHLOROCARBONS . IN A CONFINED AREA
VAPS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE: IARC MONO, SUPP, VOL
7, PG 194, 1987:GROUP 2B. NTP 7TH ANNUAL REPORT ON CARCINS, 1994:
(SUPDAT)
Effects of Overexposure:HLTH HAZ: IN HIGH CONC ARE ANESTHETIC. IRRITANT
TO SKIN & UPPER RESP SYSTEM. OVEREXP MAY RESULT IN LIGHT
HEADEDNESS, STAGGERING GAIT, GIDD & POSS NAUS. HARMFUL/FATAL IF
SWALLOWED. CHRONIC: REPORTS HAV E ASSOC RPTD & PRLNG OVEREXP TO
SOLVENTS WITH PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. ALSO KIDNEY
& LIVER DAMAGE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHALATION: REMOVE PATIENT TO FRESH AIR. EYES: FLUSH WITH
WATER FOR AT LEAST 15 MINUTES. SKIN: WASH WITH SOAP AND WATER.
INGESTION: CALL MD IMMEDIATELY. DO NOT INDUCE VOMITING.

Flash Point Method:TOC
Flash Point:<20F,<-7C
Lower Limits:SEE INGS
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD PRESSURE DEMAND SCBA &
FULL PROTECTIVE EQUIP . WATER MAY BE INEFFECTIVE - WATER MAY BE
USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:THERMAL DECOMP PRODS MAY INCL HCL &
PHOSGENE . DO NOT SPRAY NEAR OPEN FLAME. KEEP AT ROOM TEMP AS EXPOS
TO DIRECT SUNLIGHT/OTHER HEAT MAY CAUSE BURSTING.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE.
AVOID BREATHING VAPORS AND REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:EXPOSURE TO DIRECT SUNLIGHT OR HEAT
MAY CAUSE BURSTING. KEEP AWAY FROM CHILDREN. DO NOT PUNCTURE OR
INCINERATE. DO NOT SPRAY NEAR FIRE OR OPEN FLAME.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT AND/OR
UV RADIATION MAY CAUSE THE FORMATION OF HCL AND/OR PHOSGENE .

Respiratory Protection:AVOID BREATHING OF VAPOR OR SPRAY MIST.
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN
.
Ventilation:PROVIDE LOC EXHST VENT IN VOL & PATTERN TO KEEP TLV OF ALL
HAZ INGREDS BELOW ACCEPTABLE LIMIT & LEL BELOW STATED LIMIT.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN: ANTIC TO BE CARCIN. ANIMAL: LUNG, LIVER, SALIVARY,
MAMMARY GLAND (TUMORS).

Boiling Pt:B.P. Text:<0F,<-18C
Vapor Pres:52 5 PSIG
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:COATINGS.
Percent Volatiles by Volume:100 WT

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:DO NOT STORE ABOVE 120F.
Hazardous Decomposition Products:BY OPEN FLAME: CARBON MONOXIDE, CARBON
DIOXIDE, HYDROGEN CHLORIDE AND PHOSGENE GAS.

Waste Disposal Methods:DO NOT INCINERATE. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS REGARDING POLLUTION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.